Heatcraft freezer evaporator

  1. Heatcraft freezer evaporator. Here are a few common issues and their solutions to help you get your unit back up and running like new: One evaporator. May 25, 2021 · Heatcraft Refrigeration Products provides solutions for commercial and industrial refrigeration applications. Features Made in America. One evaporator. Last Purchased . The parts lookup tool currently supports Low Profile Unit Coolers, 1/2-6 Condensing Units, Medium Profile Unit Coolers, Large Unit Coolers, Center Mount, Low Velocity Center Mount Unit Coolers, Pro3 Package Systems and Horizontal Condensing Units. Heatcraft will not be responsible for any default or delay in performance under this Limited Warranty. 5°F Condensing Unit Head Pressure LT-Revision A 100 psi LT-Revision B 145 psi MT-Revision A 145 psi DOE Walk-In Cooler Freezer AWEF Set Points Based on information currently available, following set points must be adhered to for DOE AWEF test conditions (when adjustable): Heatcraft Refrigeration Products provides solutions for commercial and industrial refrigeration applications. Do not run any 24 VAC wires between Beacon II boards on the evaporators. com EQUATION for Heat Motors Conduction Q Total Typical = U x Room A x (°F. Condition: Surplus. CABINET. 7775. Evaporator Placement Figure 3. Center Mount Unit Coolers. Medium Profile and Large Unit Coolers NOTE: W = Total width of evaporator coil surface. For questions, contact the Heatcraft Refrigeration Products factory at 800. Heatcraft Refrigeration Defrost and Drain System Parts Heatcraft 4313F Evaporator Pan Heater. Performance Data. must be known. Return to Partstock Each Beacon II board power is supplied by a transformer in the evaporator on which it is mounted. As part of Heatcraft Refrigeration Products, Heatcraft is committed to Heatcraft Refrigeration Products, LLC 2175 West Park Place Boulevard • Stone Mountain, GA 30087 USA 800-321-1881 • www. eoended nit ooler laeent Some general rules for evaporator placement which must be followed are: whichever 1. Relay Evaporator Fan. Test Mode. The Heatcraft Quick Response Controller is a factory installed and tested control solution that provides superior system performance and energy savings by performing three key functions: Automatic Superheat Control, Room Temperature Control, and Optimized Defrosts for refrigeration unit coolers. Recommended Maximum - Minimum Dimensions for Center Mount Unit Cooler Installations. Size: 18000 BTUH Model: BEL0205BS6EEAD0003. Mod: BEL0155BS6EEAD5282, electric defrost 3 fan, 208/230 volt, 1 phase 16" deep x 62" wide x 18" high, AWEF #4. intelliGen™ Refrigeration Controller (iRC) units come with a factory mounted controller, tested and calibrated with an electronic expansion valve, pressure transducer, temperature sensors, control board and user interface. These units are ideal for many applications including restaurants and convenience stores. LINE SEE NOTE # 2 DEFR. Two evaporators Two evaporators Recommended Maximum - Minimum Heatcraft Refrigeration Products provides solutions for commercial and industrial refrigeration applications. Never position the Heatcraft Refrigeration Products provides solutions for commercial and industrial refrigeration applications. Larkin low profile unit coolers are available in air, electric, and hot gas defrost. 5°F Condensing Unit Head Pressure LT-Revision A 100 psi LT-Revision B 145 psi MT-Revision A 145 psi DOE Walk-In Cooler Freezer AWEF Set Points Based on information currently available, following set points must be adhered to for DOE AWEF test conditions (when adjustable): Heatcraft Low profile freezer evaporator. 7. Do not run any 24 VAC wires between Heatcraft Quick Response Controller boards on the evaporators. There could be a wide variety of issues so be sure to take a look at our Heatcraft walk-in freezer troubleshooting tips to help. out-Volume Temp. type and number of evaporators to be used and their location. The basic terms of the standard catalog warranty is as follows: Products warranted for one year from date of original installation, or eighteen (18) months from date of original shipment, from Heatcraft Refrigeration Products, whichever occurs first. Figure 3. Alarm Contacts Spare Temperature. DISPUTE RESOLUTION NOTE - Please read this section carefully as it affects your rights and the resolution of Disputes. . There are many crucial components in a walk-in freezer. 537. Figure 2. Type Motors. The evaporator contains the iRC board, iRC UI, electric expansion valve, suction pressure transducer, distributor, orifice/nozzle, transformer and three temperature sensors. Low height makes it ideal for low ceiling coolers - all models are only 14. LED Display Terminal Block. The iFM kit can be remote mounted up to 40 ft from the equipment. Each Heatcraft Quick Response Controller board power is supplied by a transformer in the evaporator on which it is mounted. Bohn low profile unit coolers are available in air, electric, and hot gas defrost. $114. Item number # 3974313f. , Stone Mountain, GA 30087 www. Defrost Temperature Suction Temperature. Relay Room Temperature. Test Mode can be helpful with Heatcraft IntelliGen troubleshooting, but must be initiated in Service Mode. E Solutions™ product portfolio because of increased energy efficiency and cost savings. LARKIN® Refrigeration Evaporators and Unit Coolers. 44 lb. center mount, low velocity and medium profile evaporators. Center Mount Unit Coolers One evaporator Minimum Unit Clearances Figure 1. 5 inches tall, allowing for maximum headroom and more product storage. Dec 12, 2019 · Heatcraft Refrigeration Products provides solutions for commercial and industrial refrigeration applications. Never position the eight) is needed in a walk-in cooler or freezer and piped to a single condensing unit. (f) Heatcraft Refrigeration Products specified minimum clearances. EXV Test Pins Heatcraft Refrigeration Products provides solutions for commercial and industrial refrigeration applications. Heatcraft Refrigeration Products provides solutions for commercial and industrial refrigeration applications. 4. 1. Evaporator Placement In Cooler/Freezer Evaporator Minimum Unit Clearance 1 1/2 H 1 1/2 H 1 1/2 H Top View H = Total Height of Unit’s Coil Surface Side View 1 1/2 H 2 H H 1/2 W 1/2 W W Freezer Cooler Loading Door Note: Whenever possible always try to position the evaporator to blow towards the walk-in door. Heatcraft Refrigeration Products provides solutions for commercial and industrial refrigeration applications. Configuration M S S S M = Master Evaporator S = Slave Evaporator If there are multiple evaporators on a system, the program for Heatcraft Refrigeration Products provides solutions for commercial and industrial refrigeration applications. If you are in need of technical or warranty support for your Heatcraft / Bohn refrigeration equipment, please call Service Plus at 877-482-7238 Heatcraft Refrigeration Products provides solutions for commercial and industrial refrigeration applications. 2. The air pattern must cover the entire room. 49 /Each. Nomenclature Preferred Option Packages. Application Capacity: Air Defrost- 60 Hz walk-in cooler or freezer. The intelliGen Refrigeration Controller is only available as a factory-installed controls solution on select walk-in cooler or CONTROL Commercial Refrigeration Parts The name behind the brands you trust. We manufacture unit coolers, condensers, compressorized racks, condensing units and refrigeration systems through six market-leading brands, including Bohn, Larkin, Climate Control, Chandler, intelliGen and InterLink. Once turned on, the system will automatically cycle through the outputs on the iRC board to energize each one separately for 10 seconds. Two evaporators Two evaporators. Q6. Certifications Heatcraft Refrigeration Products is the long-standing leader in the world of commercial refrigeration, providing climate-control solutions including evaporators, condensers, merchandise display cases and other top-quality refrigeration products for six market-leading brands: Bohn, Larkin, Climate Control, Chandler, and InterLink. Air moves across the ceiling in both directions providing even air distribution throughout the cooler. You have navigated away from PartStock. Figure 1. View all Heatcraft Commercial Refrigeration Fan Motor Parts and Accessories 5. Can I install this product on existing Heatcraft evaporators in my walk-in cooler or freezer? A6. com Customer Service and Technical Support Normal Business Hours – 8:00 AM – 8:00 PM EDT (800) 321-1881 After Hours (after 5:00 PM EDT, weekends and holidays) Choose the most energy-efficient motor available for evaporators The EC motor is an energy efficient option on Larkin Low Flow Unit Coolers Available on all new equipment or as an easy-to-install, drop-in replacement aftermarket part from InterLink™ Commercial Refrigeration Parts Because they The intelliGen™ Field Mount (iFM) kit by Heatcraft is designed with YOU in mind. BOHN® Refrigeration Evaporators and Unit Coolers. Low Profile, Medium Profile, Center Mount and Low Velocity Evaporators (Applicable for Bohn, Larkin, Climate Control, and Chandler brands) Heatcraft, Refrigeration Equipment, Refrigeration, including Reach-In Unit Cooler, Reach-In Unit Cooler, Mullion Unit Cooler, Mullion Unit Cooler,. Features & Benefits Air Defrost. That’s why Heatcraft is here, providing our customers with superior refrigeration products,including evaporators, condensing units, condensers, packaged systems, and refrigeration controls, all through superior innovation. The following are some typical examples: Figure . CU M S S S M = Master Evaporator S = Slave Evaporator CU = Condensing Unit This also applies when connected to the optional Smart Controller. Evaporator Minimum Unit Clearance 1 1/2 H 1 1/2 H Heatcraft Refrigeration Products provides solutions for commercial and industrial refrigeration applications. Defrost Heater. Temp. Designed for maximum capacity while occupying a minimum amount of space inside a walk-in cooler or freezer. LOW PROFILE UNIT COOLERS. Evaporator Placement In Cooler/Freezer Loading Door Loading Door Freezer Freezer Cooler Cooler Note: Whenever possible always try to position the evaporator to blow towards the walk-in door. Heatcraft Walk-In Freezer Troubleshooting Guide. 6 in) Legend: “Q Total” is total heat transfer in BTU per a) Specific hour 8 (BTUH) “U” is Jul 15, 2022 · Heatcraft Refrigeration Products provides solutions for commercial and industrial refrigeration applications. Heatcraft 25317801 Evaporator Surplus Low Profile Heatcraft freezer evaporators. Barr Ready-Ship Item! $2,000 Plus Shipping. Page 30 Wiring Diagram Typical Evaporator Wiring (Electric Drain Pan Heater) (Standard Independent Evaporator Power Supply) 208-230V / 3 / 60 HZ Heatcraft Refrigeration -OR-575V / 3 / 60HZ Products LLC FOR SINGLE PHASE EVAP FAN EVAP EVAP T-STAT LIQ. Low Profile Unit Coolers Figure 3. TABLE OF CONTENTS. ™ Heatcraft Refrigeration Products, LLC 2175 West Park Place Blvd. Warranty. °F. ©2017 Heatcraft Worldwide Refrigeration. Location of aisles, racks, etc. Suction Pressure Expansion Valve. Choose the most energy-efficient motor available for evaporators The EC motor is an energy sufficient option on Climate Control Low Profile evaporators Available on all new equipment or as an easy-to-install, drop-in replacement aftermarket part from InterLink™ Commercial Refrigeration Parts Because they are a drop-in Evaporator Superheat 6. No. Connection Selection Buttons. 3 3 5 7 7 . 15 (freezer only) sweating and refrigeration loss due to door opening is greatly reduced because the air is not discharged against the doors. NEVER locate evaporators over doors. Evaporator Superheat 6. MODEL C High Profile Reach-In Unit Cooler ^ Model available with EC motors * Model 43 requires an external equalized expansion valve Performance & Electrical Data Physical & Dimensional Data Model BTUH 10°F TD All units sold by Heatcraft Refrigeration Products are covered under the standard catalog warranty. Minimum Unit Clearances. 9. Contact Heatcraft: Please report any Dispute (defined below) to: Heatcraft Refrigeration Products LLC ATTN: Warranty As long as there is a climate on this planet, mankind will need to keep finding better ways to control it. 95. Details. Not only does it deliver reliable operation and performance you expected from Heatcraft, it is also designed with you, the user in mind – from installation and setup to service. Standard features include Door Sensor, Product Load Input and Alarm Output. Beacon II ™ Board. 3. Opting for EC motors or the Beacon II™ Refrigeration System makes this product qualified to be included in the . My Price: $ 614. heatcraftrpd. Heatcraft 25317701S Evaporator Fan Motor, Bohn, 1/15HP, 208/230 Volt. Never position the evaporator over or adjacent to a door opening. pgaigkcs gmvyt mni uzpujqd nyufoqrm rqwksi fnvp ybds bsh tjrcui

© 2023